Volvo V60 T5 AWD
Car parts and drivetrain components for Volvo V60 T5 AWD. Always check the fit before ordering.
Products for Volvo V60 T5 AWD
- Position: Outer
- Seal diameter: 54,1 mm
- Inner splines: 28
- Outer splines: 40
- Number of centre bearings: 2
- Number of joints: 2
- Total length: 2,140 mm
- Position: Front right
- Total length: 993 mm
- Splines gearbox side: 28
- Splines wheel side: 40
- Position: Front left
- Total length: 615 mm
- Splines gearbox side: 31
- Splines wheel side: 40
- Position: Front left
- Total length: 600 mm
- Splines gearbox side: 31
- Splines wheel side: 40
- Position: Rear, Inner
- Seal diameter: 35 mm
- Inner splines: 29
- Diameter: 35 mm
- Splines gearbox side: 26
- Position: Front left, Inner
- Seal diameter: 36 mm
- Inner splines: 27
- Diameter: 36 mm
- Splines gearbox side: 31
- Position: Front left, Inner
- Inner splines: 27
- Total length: 158 mm
- Splines gearbox side: 31
- Position: Front left
- Total length: 539 mm
- Splines gearbox side: 31
- Splines wheel side: 40
- Position: Rear left, Rear right
- Total length: 760 mm
- Splines gearbox side: 23
- Splines wheel side: 36
- ABS teeth: 44
- Position: Front right
- Total length: 947 mm
- Splines gearbox side: 26
- Splines wheel side: 36
- Position: Front right
- Total length: 1,010 mm
- Splines gearbox side: 28
- Splines wheel side: 40
- Position: Front left, Inner
- Seal diameter: 31 mm
- Inner splines: 26
- Diameter: 31 mm
- Splines gearbox side: 26
- Position: Rear, Outer
- Seal diameter: 56 mm
- Inner splines: 29
- Diameter: 56 mm
- ABS teeth: 88
- Position: Outer
- Inner splines: 29
- Outer diameter: 73 mm
- Splines wheel side: 36
- ABS teeth: 44
- Position: Inner
- Inner splines: 29
- Outer diameter: 71 mm
- Splines wheel side: 23
- Position: Outer
- Seal diameter: 54 mm
- Inner splines: 28
- Outer splines: 40
- Number of centre bearings: 2
- Number of joints: 4
- Total length: 2,150 mm
Frequently Asked Questions about Drivetrain Parts for Volvo V60 T5 AWD
How do I know if my Volvo V60 T5 AWD needs a new drive shaft?
The most common signs are vibrations under acceleration or clicking noises when cornering. If vibrations are felt through the steering wheel, it is often the front shafts, whilst vibrations through the seat can point to issues with the rear drive shafts or the propeller shaft.
Do drive shafts from a front-wheel-drive V60 fit a T5 AWD?
No, the drive shafts on AWD models often have different lengths and spline configurations to mate properly with the angle gear and the rear differential. Always select your exact make, model and engine to find the correct version.
What causes propeller shaft vibrations on a V60 T5 AWD?
Vibrations in the propeller shaft are usually caused by worn universal joints, a failing centre bearing, or a lost balance weight on the shaft. They can also be caused by rubber couplings at the ends perishing and cracking.
Can I replace just the outer CV joint instead of the entire drive shaft?
Yes, on the Volvo V60 T5 AWD it is often possible to replace only the outer CV joint if the shaft itself is otherwise undamaged. This is a cost-effective solution if the fault is confined to the joint bearings.
How does the fitment guarantee work at CVJoint24?
Our fitment guarantee means that if you select your car's make, model and engine and order the recommended part, we guarantee it will fit. In the unlikely event that it does not fit, we will help you find the correct part without any fuss.
Why is it important to inspect the CV boots on my Volvo?
The CV boot protects the CV joint from dirt, water and road salt whilst keeping the lubricating grease inside. A split boot quickly leads to joint failure, so replacing a damaged boot early can save you the cost of a complete CV joint.