Volvo S80 T6 AWD
Car parts and drivetrain components for Volvo S80 T6 AWD. Always check the fit before ordering.
Products for Volvo S80 T6 AWD
- Position: Outer
- Seal diameter: 57,5 mm
- Inner splines: 26
- Outer splines: 40
- Position: Outer
- Seal diameter: 57,5 mm
- Inner splines: 27
- Outer splines: 40
- Number of centre bearings: 2
- Number of joints: 4
- Total length: 2,160 mm
- Position: Rear
- Number of centre bearings: 2
- Number of joints: 4
- Total length: 2,146 mm
- Position: Front left
- Total length: 526 mm
- Splines gearbox side: 31
- Splines wheel side: 40
- Position: Rear left, Rear right
- Total length: 749 mm
- Splines gearbox side: 26
- Splines wheel side: 36
- ABS teeth: 44
- Position: Rear left, Rear right
- Total length: 760 mm
- Splines gearbox side: 23
- Splines wheel side: 36
- ABS teeth: 44
- Position: Front left, Inner
- Seal diameter: 31 mm
- Inner splines: 26
- Diameter: 31 mm
- Splines gearbox side: 26
- Position: Rear, Inner
- Seal diameter: 35 mm
- Inner splines: 29
- Diameter: 35 mm
- Splines gearbox side: 26
- Position: Front right, Inner
- Inner splines: 27
- Total length: 620 mm
- Splines gearbox side: 28
- Position: Rear, Outer
- Seal diameter: 56 mm
- Inner splines: 29
- Diameter: 56 mm
- ABS teeth: 88
- Position: Front right
- Total length: 947 mm
- Splines gearbox side: 26
- Splines wheel side: 36
- Position: Front right
- Total length: 990 mm
- Splines gearbox side: 28
- Splines wheel side: 40
- Total length: 1,002 mm
- Splines gearbox side: 26
- Splines wheel side: 36
- Total length: 582 mm
- Splines gearbox side: 26
- Splines wheel side: 36
- Position: Outer
- Inner splines: 22
- Outer diameter: 84 mm
- Splines wheel side: 36
- ABS teeth: 44
- Position: Inner
- Inner splines: 22
- Outer diameter: 84 mm
- Splines wheel side: 26
- Position: Outer
- Inner splines: 29
- Outer diameter: 73 mm
- Splines wheel side: 36
- ABS teeth: 44
Frequently asked questions about drivetrain parts for Volvo S80 T6 AWD
How do I know if the propeller shaft on my Volvo S80 T6 AWD needs replacing?
Common signs include vibrations felt throughout the entire car, especially at higher speeds, or a thumping noise from underneath when accelerating. If the centre bearing is worn, a whining noise may also develop.
Why does my car vibrate under acceleration?
On a Volvo S80 T6 AWD, vibrations during acceleration are often caused by a worn inner CV joint. Because the T6 engine produces high torque, these joints wear faster than on less powerful models.
Can I replace just the CV joint, or do I need to replace the entire drive shaft?
It is often possible to replace just the outer CV joint if the shaft itself is otherwise undamaged. However, when the inner joint is worn, we often recommend replacing the complete drive shaft to ensure long-term balance.
What does the fitment guarantee at CVJoint24 mean?
It means that when you select your vehicle's make, model and engine variant and order the part we recommend, we guarantee it will fit your Volvo S80 T6 AWD. If it unexpectedly does not fit, we will help you find the correct one.
How does a split CV boot affect the drivetrain?
A split CV boot allows the lubricating grease to escape and dirt to penetrate the CV joint. This causes extremely rapid wear and can lead to complete failure if not addressed immediately.
Are there different propeller shafts for the S80 T6 AWD?
Yes, there are different versions depending on the model year and chassis number. We currently stock four different variants to cover the technical variations within the S80 range.