Volkswagen Caddy
Car parts and drivetrain components for Volkswagen Caddy.
Products for Volkswagen Caddy
- Position: Outer
- Seal diameter: 59 mm
- Inner splines: 27
- Outer splines: 36
- Joint diameter: 97,95 mm
- Position: Front left
- Flange diameter: 108 mm
- Total length: 523 mm
- Splines wheel side: 36
- Position: Front right
- Flange diameter: 108 mm
- Total length: 806 mm
- Splines wheel side: 36
- Position: Inner
- Seal diameter: 100 mm
- Inner splines: 33
- Joint diameter: 100 mm
- Position: Front left
- Flange diameter: 119 mm
- Total length: 475 mm
- Splines wheel side: 36
- Position: Front left
- Total length: 405 mm
- Splines gearbox side: 28
- Splines wheel side: 27
- Position: Front right
- Flange diameter: 119 mm
- Total length: 754 mm
- Splines wheel side: 36
- Position: Front left
- Flange diameter: 108 mm
- Total length: 486 mm
- Splines wheel side: 36
- Position: Front right
- Flange diameter: 108 mm
- Total length: 780 mm
- Splines wheel side: 36
- Position: Rear
- Number of centre bearings: 1
- Number of joints: 2
- Total length: 2,179 mm
- Position: Front right
- Flange diameter: 108 mm
- Total length: 600 mm
- Splines wheel side: 36
- Position: Front left
- Total length: 562 mm
- Splines gearbox side: 37
- Splines wheel side: 36
- Position: Front right
- Total length: 910 mm
- Splines gearbox side: 37
- Splines wheel side: 36
- Position: Front left
- Flange diameter: 108 mm
- Total length: 488 mm
- Splines wheel side: 36
- Position: Outer
- Seal diameter: 59,5 mm
- Inner splines: 28
- Outer splines: 36
- Position: Front left
- Flange diameter: 100 mm
- Total length: 524 mm
- Splines wheel side: 36
- Position: Front right
- Flange diameter: 100 mm
- Total length: 815 mm
- Splines wheel side: 36
- Position: Inner
- Seal diameter: 59 mm
- Inner splines: 33
- Outer splines: 36
- Position: Outer
- Seal diameter: 60 mm
- Inner splines: 30
- Outer splines: 36
- Joint diameter: 89,9 mm
- Number of centre bearings: 1
- Number of joints: 1
- Total length: 2,160 mm
- Position: Front right
- Flange diameter: 94 mm
- Total length: 773 mm
- Splines wheel side: 22
Frequently Asked Questions about Drivetrain for Volkswagen Caddy – High-Quality Spare Parts
How do I know whether the inner or outer CV joint is faulty on my Caddy?
A faulty outer CV joint usually produces a clicking noise when turning, whereas a worn inner CV joint tends to cause vibrations through the car under acceleration, whether you are cornering or driving straight ahead.
Does the same drive shaft fit all Volkswagen Caddy models?
No, drive shafts vary depending on the model year, engine type (e.g. TDI or TSI), and whether the vehicle has a manual gearbox or DSG. Always select your car's make, model and engine to find the correct version.
Why does the ABS ring fail on the Volkswagen Caddy?
The ABS ring is exposed to moisture and road dirt. Over time, rust can develop underneath the ring, causing it to expand and eventually crack. This disrupts the sensor signal and triggers the ABS warning light.
Do I need to replace the entire drive shaft if only the boot is split?
No, if you catch a split CV boot early and the joint is still quiet and free from dirt, it is sufficient to replace the boot and repack it with fresh grease. However, if the joint has already started making noise, it must be replaced.
Are propeller shafts fitted to all Caddy models?
A propeller shaft is only fitted to Volkswagen Caddy models with 4MOTION (all-wheel drive). Front-wheel drive versions do not have a prop shaft.
Is it difficult to replace a drive shaft on a Caddy yourself?
It requires proper tools and some mechanical experience, as you need to undo parts of the suspension and the hub nut. However, for a DIY mechanic with the right equipment, it is a perfectly manageable job.
How many splines does a CV joint for the Volkswagen Caddy have?
The number of splines varies across different versions, often between 22 and 36 teeth on the outer side. It is therefore essential to check the exact specifications for your vehicle's drivetrain.